Product ID:TURCO 6628
MSDS Date:02/06/1991
FSC:6810
NIIN:00F036835
MSDS Number: BVSLT

TURCO PRODS INC SUB OF ELF ATOCHEM

7300 BOLSA AVE
WESTMINSTER, CA 92684-3600
US

Emergency Phone: 202-483-7616/714-890-3600

Info Phone: 714-890-3600/202-483-7616

Preparer: JOHN F GRAINGER

Cage: EO507

TURCO PRODUCTS, INC. DIVISON OF ELF ATOCHEM NORTH AMERICA

PHILADELPHIA, PA 19103-3222 US

Telephone: 215-419-7890

Cage: 61102

ETHYL ACETATE

CAS: 141-78-6

RTECS: AH5425000

Fraction By Weight: 40%

OSHA PEL 1400 MG/CUM

ACGIH TLV: 1400 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 35-40%WT

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 10%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

TOLUENE (IARC - GROUP 3) *94-3*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 20-25%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE-SEVERE IRRITATION.
SKIN: MODERATE-SEVERE IRRITATION, READILY ABSORBED IN TOXIC
AMOUNTS. INHALATION: VAPORS-MODERATE IRRITATION; MIST-SEVERE
RESPIRATORY IRRITATION, POSSIBLE LUNG DAMAGE. INGESTION:
MODERATE-SEVERE IRRITAITON OF GI TRACT. CHRONIC: AROMATIC
HYDROCARBONS-KIDNEY/LIVER DAMAGE/CNS DEPRESSION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DRYING, DIZZINESS, HEADACHE,
NARCOSIS, NAUSEA, DEFATTING
Medical Cond Aggravated by Exposure:PREEXISTING KIDNEY/LIVER
DYSFUNCTIONS.

First Aid:EYES: FLUSH W/LARGE VOLUMES OF WATER FOR 15 MINS. SKIN: FLUSH
W/LARGE VOLUMES OF WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH
AIR. GIVE OXYGEN/CPR IF NEEDED. INGESTION: DON'T INDUCE VOMITING
EXCEPT ON ADVICE OF COMPETENT MEDICAL PERSONNEL. IF VOMITING
OCCURS SPONTANEOUSLY, KEEP HEAT BELOW HIP. IF CONSCIOUS GIVE LARGE
VOLUMES OF MILK/WATER. (SEE SUPP)

Flash Point Method:TCC
Flash Point:25F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE SELF-CONTAINED RESPIRATORY PROTECTION.
Unusual Fire/Explosion Hazard:VAPORS FROM THIS PRODUCT ARE HEAVIER THAN
AIR & MAY TRAVEL ALONG THE GROUND TO BE IGNITED AT A POINT REMOTE
FROM MATERIAL HANDLING AREA.

Spill Release Procedures:CONTAIN. STOP LEAK AT SOURCE W/OUT RISK.
VENTILATE & EVACUATE AREA. PUMP LIQUID INTO DOT-APPROVED DRUMS FOR
DISPOSAL. ABSORB REMAINING LIQUID ONTO INERT ABSORBENT & PLACE IN
DOT-APPROVED DRUMS FOR DIS POSAL. WASH AREA W/WATER & COLLECT
WASHINGS.

Handling and Storage Precautions:STORE IN DRY PROTECTED AREA AWAY FROM
STRONG OXIDIZING AGENTS, ACIDS & ALKALIES. METAL CONTAINERS SHOULD
BE FITTED W/A BONDED GROUND WIRE.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN FLAMMABLE VAPORS IN
DANGEROUS AMOUNTS.

Respiratory Protection:TLV EXCEEDED, A NIOSH-APPROVED SCBA, POSITIVE
PRESSURE HOSE MASK/AIR LINE MASK W/FULL FACE PIECE & OPERATED IN A
POSITIVE PRESSURE MODE IS ADVISED. GOOD VENTILATION/LIMITED
EXPOSURE TIME: FULL FACE MA SK W/ORGANIC VAPOR CARTRIDGE/CANISTER.
Ventilation:SUFFICIENT MECHANICAL TO KEEP CONCENTRATION BELOW TLV.
Protective Gloves:NEOPRENE/VITON
Eye Protection:FACE SHIELD/GOGGLES
Other Protective Equipment:BOOTS & APRON MADE OF NEOPRENE/VITON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS & FACE W/SOAP & WATER BEFORE SMOKING/EATING.
Supplemental Safety and Health
FIRST AID CONT'D: NEVER ATTEMPT TO INDUCE VOMITING/GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL
CASES. REPAIR & MAINTENACE OF CONTAMINATED EQUIPMENT: RELIEVE
PRESSU RE, COVER OPENINGS, CLEAR EXTERIOR & INTERIOR W/WATER.
COLLECT FLUSHING FOR DISPOSAL. USE PROTECTIVE EQUIPMENT.

Boiling Pt:B.P. Text: 175F
Vapor Pres: 60
Vapor Density:>1
Spec Gravity:0.85
Evaporation Rate & Reference:(BU AC=1): 3
Solubility in Water:SLIGHT
Appearance and Odor:WATER WHITE LIQUID W/ESTER ODOR
Percent Volatiles by Volume: 100

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALIES & OXIDIZERS
Hazardous Decomposition Products:CO, CO2 & OTHER TOXIC VOLATILE ORGANIC
COMPOUNDS

Waste Disposal Methods:KEEP CONCENTRATE & WASH WATER FROM ENTERING
SEWERS/WATERWAYS. DISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS. FLAMMABLE LIQUID NA1993. WIPE CLOTHS CONTAMINATED
W/PRODUCT SHOULD BE COLLECTED IN CLOS ED METAL CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.